相关杂志相关协会相关书籍
热门关键词:干燥设备  闪蒸干燥机  旋转闪蒸干燥机  真空耙式干燥机  振动流化床  喷雾干燥机  桨叶干燥机  盘式干燥机  振动筛  离心泵  分散机
您现在的位置:首页 >> 泵阀设备 >> 计量泵

进口液压隔膜计量泵(欧美进口品牌)

产品关键词:进口液压隔膜计量泵 进口液压隔膜计量泵 进口液压隔膜计量泵 进口液压隔膜计量泵
  • 产品名称:进口液压隔膜计量泵(欧美进口品牌)
  • 产品编号:
  • 产品商标:GRIMM
  • 产品规格:空
  • 参考价格:面议
  • 更新时间:2020/12/14 14:26:50
  • 点击次数:477次

英国GRIMM格林进口液压隔膜计量泵 UK GRIMM Imported hydraulic diaphragm metering pump

进口液压隔膜计量泵.jpg

英国GRIMM格林进口液压隔膜计量泵概述: 

          泵的液力端和隔膜组成工作腔,由活塞驱动的液压油均匀作用于隔膜做周期性变形、从而驱动隔膜做往复运动的可调节流量的容积泵,叫液压隔膜计量泵。

英国GRIMM格林进口液压隔膜计量泵特点:

 

1、无动密封,无泄漏,维修方便,低噪音,使用方便。
2、工作压力可达69MPa,计量精度可达±1%;单缸泵流量范围:0.2L/h-12000L/h。
3、计量精度优于机械隔膜泵,密封性能优于柱塞泵。
4、流量大小控制通过调节冲程长度和变频调速来实现,配冲程调节器或变频可以实现远程自动控制。
5、介质的使用温度不宜超过100℃,不宜低于-30℃,否则影响隔膜寿命。
6、新型的三阀结构,限位补油机构的应用,即保证液压腔内液压油的充满度,又避免了补油过量,防止液压冲击,从而使隔膜两侧受力平衡,提高隔膜的使用寿命。隔膜寿命可提高到8000h以上。
7、在输送特殊介质时,可采用双隔膜带隔膜破裂报警装置,防止隔膜破裂时,介质与液压油混合引起事故。

英国GRIMM格林进口液压隔膜计量泵技术参数: 

 

流量范围:10-23000L/h
压力范围:0.8-50MPa
电机功率:0.37-11kw
额度电压:110V、220V、380V、420V,50HZ、60HZ
驱动方式:两相、三相标准等级或防爆电机
流量控制:手动控制或自动控制(接收4-20mA信号)
连接方式:直管焊接、法兰
过流材质:SS304、SS316、SS304+PTFE、SS316+PTFE
隔膜材质:PTFE
柱塞材质:SS304+陶瓷、LSS316+陶瓷
阀座材质:SS316
单向阀材质:SS304、SS316
阀       球:ZrO2、陶瓷、SS304、SS316
防护等级:IP55、IP54
环境温度:-30℃~80℃

 

 

英国GRIMM格林进口液压隔膜计量泵应用领域: 

             适用于由一般常温清水直至具有强腐蚀,易挥发、易结晶、易燃、易爆、剧毒、恶臭、腐蚀性强,比重大、中等粘度,有放射性或其它贵重液体等。同时也可输送悬浮液体,对一些为防止隔膜破裂后,介质与液压油混合引起事故,对易燃易爆、剧毒及贵重液体时,可选用双隔膜计量泵并带隔膜破裂报警装置。

UK GRIMM Imported hydraulic diaphragm metering pump summary:

           The hydraulic end of the pump and a diaphragm chamber, the hydraulic oil piston driven by the uniform effect on diaphragm periodic deformation, thereby driving the diaphragm pump with adjustable flow volume do reciprocating motion, called hydraulic diaphragm metering pump.

 

UK GRIMM Imported hydraulic diaphragm metering pump characteristic: 

 

 

 

 

 

 

 

 

1. No action seal, no leakage, easy maintenance, low noise, easy to use.

2. Work pressure up to 69MPa, measuring accuracy of up to + 1%; single cylinder pump flow range: 0.2L/h-12000L/h.

3. Measuring accuracy is better than mechanical diaphragm pump, sealing performance better than piston pump.

4. The flow size control by adjusting the length of stroke and variable frequency speed to achieve, with stroke regulator or frequency conversion can achieve remote automatic control.

5. The use of medium temperature should not exceed 100 degrees, should not be lower than -30 degrees, or affect the diaphragm life.

6. The new three valve structure, limiting the application of the oil feeding mechanism, which is to ensure the full degree of the hydraulic oil inside, and avoid excessive oil filling, to prevent hydraulic shock, so that both sides of the diaphragm force balance, improve the service life of the diaphragm. Diaphragm life can be increased to more than 8000h.

7. In the transport of special media, you can use double diaphragm with diaphragm rupture alarm device, to prevent the diaphragm rupture, the media and hydraulic oil mixed accident.

UK GRIMM Imported hydraulic diaphragm metering pump technical parameter:

 

 

 

 

 

 

 

 

 

 

 

Flow range: 10-23000L/h

Pressure range: 0.8-50.0MPa

Motor power: 0.37-11kw

Limit voltage: 110V, 220V, 380V, 420V, 50HZ, 60HZ

Driving mode: two phase, three phase standard class or explosion-proof motor

Flow control: manual control or automatic control (receive 4-20mA signal)

Connection: straight pipe welding, flange

Over current material: SS304, SS316, SS304+PTFE, SS316+PTFE

Diaphragm material: PTFE

Plunger material: SS304+ ceramic, LSS316+ ceramic

Seat material: SS316

Check valve material: SS304, SS316

Valve ball: ZrO2, ceramic, SS304, SS316

Protection level: IP55, IP54

Ambient temperature: -30 ~ 80 DEG C

UK GRIMM Imported hydraulic diaphragm metering pump application area:

 

 

 

 

 

 

         It is suitable for general water at ordinary temperature, until it has strong corrosion, volatile, easy to crystallize, flammable, explosive, poisonous, foul smelling, corrosive, more important, medium viscosity, radioactive or other precious liquid, etc.. At the same time, it can also convey some of the suspension liquid, to prevent rupture of diaphragm after mixed medium with hydraulic oil caused by accident, flammable and explosive, toxic and expensive liquid, can use double diaphragm metering pumps and diaphragm rupture alarm device.

*主 题:
*公司名称:
*联 系 人:
 电 话: 两种联系方式
必须填写一个
 电子邮件:
*反馈内容:
*验 证 码: 点击刷新验证码
免责声明:以上信息由企业自行提供,该企业负责信息内容的真实性、准确性和合法性。化工机械网对此不承担任何保证责任。
关于我们 - 联系我们 - 本站公告 - 服务条款 - 网站帮助 - 商务服务 - 法律声明 - 法律顾问 - 友情链接 - 在线咨询 - 网站地图
全国客服热线:400-667-8871
Copyright © 2004-2013 中国化工机械网 WWW.CHEMM.CN 江苏东网信息科技有限公司 版权所有
  • 广告业务(图片广告、会员申请):400-667-8871
  • 设备采购(设备采购、导购咨询):400-667-8871
  • 信息编辑(会员审核、信息发布):400-667-8871
  • 媒体合作( 展会、协会、杂志 ):400-667-8871
  • 人力资源:400-667-8871
  • 图文传真:0519-89897519
苏ICP备05005804号-7 增值电信业务经营许可证 苏B2-20110228 E-mail:
http://www.chemm.cn/Sample/Pro3482558.html